Home  |  Contents 

Windmills
  Forum Index : Windmills         Section
Subject Topic: 1000 W Wind Grid Tie Inverter repair Post ReplyPost New Topic
Author
Message << Prev Topic | Next Topic >>
DaveP68
Senior Member
Senior Member
Avatar

Joined: 25 November 2014
Location: New Zealand
Online Status: Offline
Posts: 237
Posted: 05 October 2017 at 4:25am | IP Logged Quote DaveP68

Flc1 had 1 of his 2 45-90 VDC 1000 W Grid Tie Inverters fail recently and sent it too me to try and repair.

As it turned out was a very simple fault traced to the Dump Load circuit. Require 2x power MOSFET's had gone short circuit. Order 2 of them at a cost of only $5 each soldered them in and it worked perfectly once powered up.

Photos of where they are (removed) on the board.



New MOSFET's installed.




The following photos are of the test rig to check it at full power output under controlled conditions.






Used a 48 VDC battery in series with a 4x 3p Delta 36 pole stator to boost power into inverter to >1200 W to test over voltage protection at full power output. Over voltage protection started to cut in at 91 VDC.

Ended up generating a maximum of 1270 W on DC side, 91.8 VDC at 13.84 Amps. Peak output power of 1080 W AC generated into Grid.

Also the cut in voltage for this inverter was increased from 45 VDC to 49.5 VDC. This was required due to dual stator set up cut in RPM ended up a to close to single stator system. The wind turbine can only start up on single inverter, so this should solve that issue which was a minor problem anyway.


Back to Top View DaveP68's Profile Search for other posts by DaveP68
 


If you wish to post a reply to this topic you must first login
If you are not already registered you must first register

  Search the forums using Google.
In the news...
 
Post ReplyPost New Topic
Printable version Printable version
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot delete your posts in this forum
You cannot edit your posts in this forum
You cannot create polls in this forum
You can vote in polls in this forum

Powered by Web Wiz Forums version 7.8
Copyright ©2001-2004 Web Wiz Guide

This page was generated in 0.1719 seconds.
Privacy Policy     Process times : 0.06, 0, 0, 0.11